Description
OBD-II Trouble Code Description for P0231 Audi
Fuel Pump Secondary Circuit Low
What does this mean?
OBD2 Code P0231 Audi definition:
The fuel pump is powered by the fuel pump relay. When the PCM (powertrain control module) activates the fuel pump relay, voltage is supplied to the fuel pump and it pressurizes the fuel system. Some vehicles have a feedback on the fuel pump supply circuit. This is simply a circuit spliced into the voltage feed to the fuel pump. The splice is usually located close to the PCM. The PCM monitors this feedback circuit to ensure that there is proper voltage being sent to the fuel pump. As it activates the fuel pump relay, it expects to see battery voltage on the feedback circuit. If it sees voltage that is too low or no voltage at all, it may set P0231 Audi.
Symptoms
Possible sumptoms of OBD code P0231 Audi
Symptoms of a P0231 Audi DTC may include: No start Start and stall Misfire Inadequate fuel supply
Causes
Possible causes of OBD code P0231 Audi
Potential causes of a P0231 Audi code include: Bad FP (fuel pump) relay Harness chafing causing open in fuel pump supply circuit Loose/damaged connectors Open in feedback circuit Fuel pump fuse blown due to short to ground NOTE: If no drivability complaints are present and P0231 Audi code is stored, suspect open in feedback circuit between splice and PCM
Possible Solutions
To diagnose fuel pump circuits there’s no replacement for a good wiring diagram. Try to locate one before attempting a complex repair. If the vehicle will start and run and no drivability complaints are present, then suspect an open in the feedback circuit between the PCM and where it splices into the fuel pump supply voltage circuit. Repair as necessary. If the vehicle doesn’t start or starts and dies due to low fuel pressure, check the fuel pump fuse. If it’s blown check for a short to ground on the fuel pump voltage supply circuit. Do this by removing the FP relay and then check the resistance between the voltage supply circuit at the fuel pump connector and ground. If you have little resistance indicating a short to ground, unplug the fuel pump and check again. If it shows high or infinite resistance after unplugging the fuel pump, replace the shorted fuel pump. If the resistance is still low after unplugging the fuel pump then repair short in the FP voltage supply circuit If the resistance check is showing that the fuel pump supply circuit is okay then re-check between the FP fuse and the FP relay. There has to be a short somewhere. Check for wiring harness chafing in certain areas. Repair as necessary. If the fuel pump fuse isn’t blown and the vehicle won’t start or starts and stalls due to low fuel pressure then remove the fuse and check that voltage is present to the fuse. Then check that voltage is traveling from the fuse to the FP relay by re-installing the FP fuse and checking for battery voltage at the FP relay. If the FP fuse or the FP relay doesn’t have voltage supplied to it, the fuel pump will not operate. Find the open in the circuit and repair as necessary. If both the FP fuse and the FP relay have sufficient voltage, remove the FP relay and install a fused jumper wire to complete the FP voltage supply circuit (Usually you do this by jumping terminals 30 & 87 in most relays-check a wiring diagram to be sure). If the fuel pump runs, replace the faulty FP relay and recheck. If the fuel pump doesn’t run check for voltage present (with jumper connected or by cycling the ignition key with FP relay installed) at the fuel pump connector at the fuel tank. If voltage is present verify that the ground circuit is intact. If both are okay, replace the fuel pump. If voltage isn’t present at the fuel pump with fused jumper wire installed, repair open in fuel pump voltage supply circuit.
The OBD2 Code Information Be Applicable For Audi:
2013 Audi TT ultra quattro Concept,2013 Audi TT RS plus,2013 Audi TTS Roadster competition,2013 Audi TTS Coupe competition,2013 Audi Sport quattro Concept,2013 Audi SQ5 TDI,2013 Audi S8,2013 Audi S7 Sportback,2013 Audi S6 Avant,2013 Audi S6,2013 Audi S4 Avant,2013 Audi S4,2013 Audi RS5 DTM,2013 Audi RS4 Avant,2013 Audi R8 e-tron Concept,2013 Audi R8 V10 plus,2013 Audi R8 V10 Spyder,2013 Audi R8 V10,2013 Audi R8,2013 Audi Q5,2013 Audi Nanuk quattro Concept,2013 Audi A8 L Hybrid,2013 Audi A8 Hybrid,2013 Audi A6 allroad quattro,2013 Audi A6 Black Edition,2013 Audi A4 allroad quattro,2013 Audi A4 Avant,2013 Audi A4,2013 Audi A3 e-tron Concept,2013 Audi A3,2013 Audi A1 quattro,2012 Audi e-bike Worthersee Concept,2012 Audi S5 Sportback,2012 Audi S5 Cabriolet,2012 Audi S5,2012 Audi RS Q3 Concept,2012 Audi RS5,2012 Audi RS3 Sportback,2012 Audi R8 GT Spyder,2012 Audi R8 Exclusive Selection,2012 Audi Q5 Hybrid quattro,2012 Audi Q3 Vail Concept,2012 Audi Q3 Jinlong Yufeng Concept,2012 Audi Q3,2012 Audi Crosslane Coupe Concept,2012 Audi A8 L Security,2012 Audi A6 L e-tron Concept,2012 Audi A6 Hybrid,2012 Audi A6 Avant,2012 Audi A6,2012 Audi A5 Sportback,2012 Audi A5 DTM,2012 Audi A5 Coupe,2012 Audi A5 Cabriolet,2012 Audi A1 amplified,2012 Audi A1 Sportback,2011 Audi Urban Spyder Concept,2011 Audi Urban Concept,2011 Audi TT Roadster,2011 Audi TT Coupe,2011 Audi TTS Roadster,2011 Audi TTS Coupe,2011 Audi S5 Sportback,2011 Audi RS5,2011 Audi R8 Spyder 5.2 FSI quattro,2011 Audi R8 Spyder 4.2 FSI quattro,2011 Audi R8 GT,2011 Audi R18,2011 Audi Q7,2011 Audi A8 L,2011 Audi A8,2011 Audi A7 Sportback,2011 Audi A3 e-tron Concept,2011 Audi A3 Sportback,2011 Audi A3 Concept,2011 Audi A3 Cabriolet,2011 Audi A3,2011 Audi A2 Concept,2011 Audi A1 clubsport quattro Concept,2011 Audi A1,2010 Audi quattro Concept,2010 Audi e-tron Spyder Concept,2010 Audi e-tron Concept,2010 Audi TT RS Roadster,2010 Audi TT RS,2010 Audi TT GT4 Concept,2010 Audi S5 Cabriolet,2010 Audi R8 V10 5.2 FSI quattro,2010 Audi Q7,2010 Audi A8 Hybrid Concept,2010 Audi A5 Sportback,2010 Audi A5 Cabriolet,2010 Audi A4 allroad quattro,2010 Audi A1 e-tron Concept,2009 Audi e-tron Concept,2009 Audi TTS Roadster,2009 Audi TTS Coupe,2009 Audi Sportback Concept,2009 Audi S6 Avant,2009 Audi S6,2009 Audi S4 Avant,2009 Audi S4,2009 Audi S3 Sportback,2009 Audi S3,2009 Audi RS6,2009 Audi R8 GT3,2009 Audi Q7 V12 TDI,2009 Audi Q5 Custom Concept,2009 Audi Q5,2009 Audi A6 allroad quattro,2009 Audi A6 Avant,2009 Audi A6,2009 Audi A4 Avant,2009 Audi A4,2009 Audi A3 Sportback,2009 Audi A3,2008 Audi TT clubsport quattro Concept,2008 Audi TT Roadster 3.2 quattro,2008 Audi TT Coupe,2008 Audi S8,2008 Audi S6,2008 Audi S5,2008 Audi S4 Cabriolet,2008 Audi RS6 Avant UK Version,2008 Audi RS6 Avant,2008 Audi RS4 Cabriolet,2008 Audi RS4,2008 Audi R8 V12 TDI Concept,2008 Audi R8 TDI Le Mans Concept,2008 Audi R8,2008 Audi Q7,2008 Audi A8 L,2008 Audi A8 4.2 TDI quattro,2008 Audi A8L W12 quattro,2008 Audi A8,2008 Audi A6 Avant,2008 Audi A6,2008 Audi A5 3.0 TDI quattro,2008 Audi A5,2008 Audi A4 US Version,2008 Audi A4 TDI Concept e,2008 Audi A4 Cabriolet,2008 Audi A4,2008 Audi A3 US Version,2008 Audi A3 TDI clubsport quattro Concept,2008 Audi A3 Cabriolet,2008 Audi A1 Sportback Concept,2007 Audi metroproject quattro Concept,2007 Audi TT clubsport quattro Concept,2007 Audi TT Roadster 2.0 TFSI,2007 Audi TT Roadster,2007 Audi TT Coupe S-line,2007 Audi TT Coupe,2007 Audi S3,2007 Audi R8,2007 Audi Q7 V12 TDI Concept,2007 Audi Q7 V12 TDI,2007 Audi Cross Coupe quattro Concept,2007 Audi Cross Cabriolet quattro Concept,2006 Audi S8,2006 Audi S6 Avant,2006 Audi S6,2006 Audi S4 Cabriolet,2006 Audi Roadjet Concept,2006 Audi RS 4 Cabriolet,2006 Audi RS 4 Avant,2006 Audi RS4,2006 Audi Q7,2006 Audi A8 Security,2006 Audi A6 allroad quattro,2006 Audi A4 Cabriolet,2006 Audi A3 2.0T,2005 Audi allroad quattro V8 4.2,2005 Audi allroad quattro V6 2.7T,2005 Audi TT quattro sport,2005 Audi TT Roadster 3.2,2005 Audi TT Roadster 1.8T,2005 Audi TT Coupe 3.2,2005 Audi TT Coupe 1.8T,2005 Audi Shooting Brake Concept,2005 Audi S4 Cabriolet,2005 Audi S4 Avant,2005 Audi S4,2005 Audi RS4,2005 Audi Q7 Hybrid Concept,2005 Audi Allroad quattro Concept,2005 Audi A8 L W12,2005 Audi A8 L 4.2,2005 Audi A8 4.2 TDI quattro,2005 Audi A8 4.2,2005 Audi A8 3.2 FSI quattro,2005 Audi A8L 4.2 TDI quattro,2005 Audi A6 Avant,2005 Audi A6 4.2 quattro Sline,2005 Audi A6 3.2,2005 Audi A6 3.0 TDI quattro,2005 Audi A6L,2005 Audi A4 DTM Edition,2005 Audi A4 Cabriolet,2005 Audi A4 Avant 3.2 quattro,2005 Audi A4 3.2 quattro,2005 Audi A4 3.0 TDI quattro,2005 Audi A4 2.0T,2005 Audi A3 2.0 TDI 3-door,2004 Audi S4 Cabriolet,2004 Audi RSQ Concept,2004 Audi RS6 plus,2004 Audi A8 L 6.0 W12 quattro,2004 Audi A8 L 3.0 quattro,2004 Audi A8 4.2 quattro,2004 Audi A8 3.7 quattro,2004 Audi A8 3.0 TDI quattro,2004 Audi A8,2004 Audi A3 Sportback quattro,2004 Audi A3 Sportback S-line,2004 Audi A3 Sportback,2004 Audi A3 3-door,2003 Audi allroad quattro,2003 Audi TT Roadster 3.2 quattro,2003 Audi TT 3.2 DSG quattro,2003 Audi Pikes Peake quattro Concept,2003 Audi Nuvolari quattro Concept,2003 Audi Le Mans quattro Concept,2003 Audi A8 L 4.2 quattro,2003 Audi A8 4.0 TDI quattro,2003 Audi A4,2003 Audi A3 3.2 V6 3-door,2003 Audi A3 3-door,2003 Audi A2,2002 Audi allroad quattro 4.2,2002 Audi allroad quattro,2002 Audi TT Roadster,2002 Audi S6 Avant,2002 Audi S6,2002 Audi S4 Avant,2002 Audi S4,2002 Audi S3,2002 Audi RS6 Sedan,2002 Audi RS6 Avant,2002 Audi RS6,2002 Audi A6,2002 Audi A4 Cabriolet 3.0,2002 Audi A4 Cabriolet 2.4,2002 Audi A4 Cabriolet 1.8 T,2002 Audi A4 Cabriolet,2002 Audi A4 Avant,2002 Audi A4,2002 Audi A3 3-door,2002 Audi A2,2001 Audi TT Coupe,2001 Audi Avantissimo Concept,2001 Audi A8 L 6.0 quattro,2001 Audi A6 Avant,2001 Audi A6,2001 Audi A4 Avant,2001 Audi A4
Note:
1. The list of automotive Makes at the right edge of the screen. The currently selected ODB-ii codes is for the Audi makes.
2. Look up the other OBD II Trouble Codes, please use the search box. Enter the 5 character trouble codes in the search box and submit the search.
3. Don’t assume a particular OBD-II code means the same for other auto manufacturers as there are many makes specific codes in use.
4. If your OBD-II trouble codes are for a different car, select that vehicle series before searching for the diagnostic codes because not all OBD2 codes used by one manufacture are used by the other makes.
5. The information contained on this site is presented for informational purposes only. We are not responsible for any actions you take on your vehicle. If you have any doubt as to repairs on your vehicle, please contact your technician.